1.土路肩滑模攤鋪機滑模施工土路肩，實現機械化連續作業，成型的土路肩培土密實度高，土路肩棱角順直，施工界面簡潔、干凈，提高施工效率。

　　1. The sliding mode paving machine for the construction of soil road shoulders achieves mechanized continuous operation. The formed soil road shoulders have high compaction and straight edges, and the construction interface is simple and clean, improving construction efficiency.

　　2.硬路肩滑模攤鋪機硬路肩滑模機主要由液壓氣缸、自動系統、撞錘、專用硬路肩橫具等4部分組成。采用該機生產可以使硬路肩直接成型澆注，并且可下嵌于土地基礎，同時成型后的硬路肩具有較高的抗沖擊強度和穩定性，其整體性強度及穩定性是遠遠優于傳統方式生產的硬路肩，鋪砌后的硬路肩順直，線形流暢，硬路肩與路面標高均達到了設計要求且平整度好。

　　2. Hard shoulder sliding mode paver The hard shoulder sliding mode paver is mainly composed of four parts: hydraulic cylinder, automatic system, hammer, and dedicated hard shoulder crossbar. The use of this machine for production allows for direct molding and pouring of hard shoulders, which can be embedded in the soil foundation. At the same time, the formed hard shoulders have high impact resistance and stability, and their overall strength and stability are far superior to those produced by traditional methods. The paved hard shoulders are straight, with smooth lines, and the elevation of the hard shoulders and road surfaces meet the design requirements and have good flatness.

　　3.中分帶填土喂料機填筑過程由攤鋪機傳送帶運送土體至中央分隔帶中，此過程只需人工配合清掃浮土。攤鋪機傳送帶底部附帶大粒徑土塊分篩裝置，可以分離出大粒徑填料，需要人工進行清除。回填完成后采用小型夯實機器跟進壓實，直至滿足設計壓實度。對于未填筑到或超過設計標高的地方進行人工修整。回填施工機械化程度高，回填效率高，回填效果好，布料均勻，能夠減少土體灑落，防止路面結構層污染效果顯著。

　　3. The filling process of the filling feeder in the median strip is carried by the conveyor belt of the paver to transport the soil to the median strip, and this process only requires manual cooperation to clean the floating soil. The bottom of the conveyor belt of the paver is equipped with a large particle size soil block screening device, which can separate large particle size fillers and requires manual cleaning. After backfilling is completed, small compaction machines are used to follow up and compact until the design compaction degree is met. Manually repair areas that have not been filled to or exceed the design elevation. The mechanization level of backfilling construction is high, the backfilling efficiency is high, the backfilling effect is good, the fabric is uniform, and it can reduce soil scattering and prevent significant pollution of the pavement structure layer.

　　4.抗離析多功能全斷面水穩攤鋪機抗離析多功能全斷面水穩攤鋪機可實現水穩基層大寬度大厚度一機代替多機、一次成型攤鋪避免了并機接縫造成的早期裂紋，接縫處離析，避免縱向接縫造成的不平整，雙振搗夯實預壓密實度高，削峰填谷找平效果好，提高了水穩層的平整度；履帶液壓自動張緊且履帶加長設計，接地面積更大，行駛更加穩定，能保證施工過程的連續性，提高整體施工效率。

　　4. Anti segregation multifunctional full section water stable paver. The anti segregation multifunctional full section water stable paver can achieve a wide and thick water stable base layer with one machine instead of multiple machines, and one-time molding paving avoids early cracks caused by parallel machine joints, segregation at joints, and unevenness caused by longitudinal joints. The double vibration compaction pre compression density is high, the peak shaving and valley filling leveling effect is good, and the flatness of the water stable layer is improved; The track is designed with automatic hydraulic tensioning and elongated tracks, providing a larger grounding area and more stable driving, ensuring the continuity of the construction process and improving overall construction efficiency.

　　5.基層雙層連鋪工藝水穩基層雙層連鋪施工工藝是指在水穩下基層攤鋪碾壓成型后，立即通過側向供料機攤鋪碾壓水穩上基層，兩層連續攤鋪后再進行覆蓋養生，即“雙層連鋪、分層碾壓、一次成型”。同時，半剛性基層采用雙層連鋪技術，其骨料最大可嵌入水穩下基層50%，由此可以形成較大的構造深度，上下基層集料咬合更佳，可有效提高層間的抗剪性能，使層間具有較好的整體性，且無明顯層間分界線。

　　5. Double layer continuous paving process for base layer Water stable base layer Double layer continuous paving construction process refers to the process of immediately paving and rolling the water stable upper base layer through a lateral feeding machine after the water stable base layer is laid and compacted, and then covering and curing it after two consecutive layers of paving, that is, "double layer continuous paving, layered rolling, and one-time molding". At the same time, the semi-rigid base layer adopts double-layer continuous laying technology, and its aggregate can be embedded into up to 50% of the water stable lower base layer, thus forming a larger structural depth. The upper and lower base layers have better interlocking of aggregate, which can effectively improve the shear resistance between layers, make the layers have good integrity, and there is no obvious interlayer boundary line.

　　6.水泥凈漿灑布車水泥凈漿灑布車采用大功率攪拌、新型灑布裝置，相較于傳統靠人力完成水泥凈漿灑布的方式，在提高施工速度的同時，能夠保證施工效果，解決了傳統施工中人力投入大、灑布效果差、安全隱患多等缺陷。水泥凈漿灑布車

　　6. Cement slurry spraying truck adopts high-power mixing and a new type of spraying device. Compared with the traditional method of manually spraying cement slurry, it can improve the construction speed while ensuring the construction effect, solving the problems of large manpower input, poor spraying effect, and multiple safety hazards in traditional construction. Cement slurry spraying truck

　　7.水穩養生覆膜機全自動水穩覆膜機解決傳統水穩養生人工覆蓋土工布效率慢等問題，實現土工布自動覆蓋養生，工人可手持遙控器自動啟停開關，極大地提高了養生覆蓋效率，確保底基層在終凝前能夠及時保水養生，有效提升實體質量。

　　7. Water stable health laminating machine Fully automatic water stable laminating machine solves the problem of slow efficiency of traditional manual coverage of geotextile for water stable health preservation, realizing automatic coverage and health preservation of geotextile. Workers can hold a remote control to automatically start and stop the switch, greatly improving the health preservation coverage efficiency, ensuring that the subgrade can be timely water preserved and cured before final setting, effectively improving the quality of the entity.

　　8.水穩邊部注漿機水穩攤鋪層邊部注漿機是一種控制漿液均勻性、注漿量的專用邊部注漿設備，可降低施工成本、減少人員配置，提高施工效率，適宜于水泥穩定碎石基層鋪設、改擴建道路及新舊水穩層結合部位應用，以提高基層邊部、結合面密實度及強度，保證施工質量。

　　8. Water stable edge grouting machine Water stable paving layer edge grouting machine is a specialized edge grouting equipment that controls the uniformity and grouting volume of the slurry. It can reduce construction costs, personnel configuration, and improve construction efficiency. It is suitable for the laying of cement stabilized crushed stone base, the expansion and reconstruction of roads, and the application of new and old water stable layer joints to improve the compactness and strength of the base edge and joint surface, and ensure construction quality.

　　9.同步碎石封層撒布車智能控制瀝青和碎石灑布量，灑布精度高，噴灑過程由計算機全程控制，同一點的瀝青和碎石撒到地面的時間間隔不超過0.5秒，極大效果增加瀝青與碎石的黏結度，最大程度的提高了路面的質量。

　　9. The synchronous gravel sealing layer spreading vehicle intelligently controls the amount of asphalt and gravel sprayed, with high spraying accuracy. The spraying process is fully controlled by the computer, and the time interval for asphalt and gravel to be sprayed on the ground at the same point does not exceed 0.5 seconds, greatly increasing the adhesion between asphalt and gravel and improving the quality of the road surface to the maximum extent.

　　10. 抗離析多功能攤鋪機抗離析攤鋪機的核心原理為采用封閉攪拌槽，使得物料滿埋輪旋，同時強制擠推可進行二次攪拌。有效改善前道工序（裝卸、運輸等）離析問題；減少結核狀離析；避免并機接縫離析；實現了路面攤鋪的高均勻度、高密實度、高平整度；實現了單機大寬度、大厚度、大粒徑、動態大幅變寬抗離析攤鋪作業，實現了瀝青和水穩的多用途攤鋪，大大提高了施工效率。

　　10. Anti segregation multifunctional paver The core principle of the anti segregation paver is to use a closed mixing tank, so that the material is fully buried and the wheel rotates, and at the same time, forced squeezing can be used for secondary mixing. Effectively improve the segregation problem in the previous process (loading and unloading, transportation, etc.); Reduce tuberculosis like segregation; Avoid segregation of parallel machine seams; Achieved high uniformity, high density, and high flatness in road paving; It has achieved single machine wide, thick, large particle size, dynamic and greatly variable width anti segregation paving operation, realizing multi-purpose paving of asphalt and water stability, greatly improving construction efficiency.

　　11. 3D智能攤鋪、碾壓成套設備施工現場的路面成套攤鋪壓實設備通過平臺全自動化監控機群設備的施工工況。通過施工現場的大屏幕，可清晰地看到設備在施工過程中的運行軌跡、下料數據、生產下單等多維度數據。智能壓實輔助系統是基于高精度北斗定位、智能傳感器、無線網絡、云平臺、大數據而開發的新一代數字智能化施工輔助系統，該系統改變了傳統攤鋪壓實作業的缺點，還可以對行車速度與壓實溫度進行語音提示，避免車速太快、溫度太低影響施工效果。同時，系統可以完整記錄每一次碾壓過程，提高施工質量和效率，降低施工測量難度和提升施工數據采集效率。

　　11. The complete set of 3D intelligent paving and compaction equipment is used to monitor the construction conditions of the road surface paving and compaction equipment on the construction site through a fully automated platform. Through the large screen on the construction site, multi-dimensional data such as the operation trajectory, cutting data, and production orders of the equipment during the construction process can be clearly seen. The intelligent compaction assistance system is a new generation of digital intelligent construction assistance system developed based on high-precision Beidou positioning, intelligent sensors, wireless networks, cloud platforms, and big data. This system changes the shortcomings of traditional paving and compaction operations and can also provide voice prompts for driving speed and compaction temperature, avoiding the impact of too fast speed and too low temperature on construction results. At the same time, the system can fully record every compaction process, improve construction quality and efficiency, reduce construction measurement difficulty, and enhance construction data collection efficiency.

　　12. 自動揭蓋篷布瀝青運輸車運輸車軌道式自動篷布通過遙控電機帶動篷布轉動裝置，使U 型鋼管支撐的篷布沿固定鋼纜平行滑動，最后由篷布轉向檔桿和轉向擋柱配合完成車斗尾端混合料的覆蓋。在實際使用中較傳統篷布覆蓋率更高，可操控性強，有效的降低了運輸過程中造成的揚塵污染。

　　12. Automatic uncovered tarpaulin asphalt transport vehicle track type automatic tarpaulin is driven by a remote control motor to rotate the tarpaulin device, allowing the U-shaped steel pipe supported tarpaulin to slide parallel to the fixed steel cable. Finally, the tarpaulin steering gear lever and steering gear column cooperate to complete the coverage of the mixture at the tail end of the vehicle bucket. In practical use, it has a higher coverage rate and stronger controllability compared to traditional tarpaulins, effectively reducing dust pollution caused during transportation.

　　13. 瀝青保溫運輸車瀝青保溫運輸車具有瀝青自流卸出、泵壓卸出、泵吸裝罐、原地輸送等功能；瀝青罐設有加熱系統，配備進口柴油燃燒器，燃燒質量好，無污染。采用獨特的導熱油系統對瀝青泵、閥加熱保溫，液壓系統驅動瀝青泵和導熱油泵，傳動可靠，操作方便。

　　13. Asphalt insulation transport vehicles have functions such as self flow unloading of asphalt, pump pressure unloading, pump suction tank loading, and on-site transportation; The asphalt tank is equipped with a heating system and imported diesel burners, which have good combustion quality and no pollution. Adopting a unique thermal oil system to heat and insulate the asphalt pump and valve, the hydraulic system drives the asphalt pump and thermal oil pump, ensuring reliable transmission and easy operation.

　　14. 瀝青透層灑布車瀝青透層灑布車配備了先進的控制系統，能夠根據輸入的灑布量和噴灑寬度及瀝青種類，自動計算瀝青泵轉數，從而實現精確的灑布。這種精確控制有助于確保施工質量，減少浪費

　　14. Asphalt prime coat spraying truck is equipped with an advanced control system that can automatically calculate the speed of the asphalt pump based on the input spraying amount, spraying width, and asphalt type, thereby achieving accurate spraying. This precise control helps ensure construction quality and reduce waste

　　16.取芯防污染器取芯防污染器可防止水流四溢，減少了因水流溢出導致的清理和重復工作，提高了工作效率，并且結構簡單，適用性強。無論是小型手持式還是大型坐立式取樣機都能適應。

　　16. Core taking anti pollution device The core taking anti pollution device can prevent water overflow, reduce cleaning and repetitive work caused by water overflow, improve work efficiency, and has a simple structure and strong applicability. Both small handheld and large seated sampling machines can adapt.

　　17.碾壓設備預警防撞系統在設備前后安裝防碰撞感知設備，防碰撞感知設備在觸碰障礙物的瞬間，感知裝置接收信號，信號傳遞到碰撞危險判斷單元，判斷單元對危險程度進行判斷識別，進而將判斷信息傳遞至剎車系統、駕駛室警示裝置進行執行，剎車并警示壓路機駕駛員前方發生碰撞。有效提高路面工程施工安全性能，增強對施工作業人員的安全防護。

　　17. The early warning and collision avoidance system for rolling equipment is equipped with collision avoidance perception devices in front and behind the equipment. When the collision avoidance perception device touches an obstacle, the perception device receives a signal, which is transmitted to the collision danger judgment unit. The judgment unit judges and recognizes the degree of danger, and then transmits the judgment information to the braking system and the driver's cab warning device for execution, braking and warning the roller driver of a collision ahead. Effectively improve the safety performance of road construction and enhance the safety protection of construction workers.

　　本文由  水泥撒布車出租  友情奉獻.更多有關的知識請點擊  http://www.dj1688.cn/   真誠的態度.為您提供為全面的服務.更多有關的知識我們將會陸續向大家奉獻.敬請期待.

　　This article is a friendly contribution from a cement spreader rental For more related knowledge, please click http://www.dj1688.cn/ Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.