清洗頻率建議

　　Suggested cleaning frequency

　　常規使用情況下，建議每使用1–2天就對水泥凈漿灑布車進行一次清洗，避免水泥漿在罐體、管路和噴嘴內結塊硬化，影響流量與噴灑均勻性，并降低泵與密封件的磨損與堵塞風險。

　　Under normal usage, it is recommended to clean the cement slurry distribution truck every 1-2 days to prevent cement slurry from clumping and hardening in the tank, pipelines, and nozzles, affecting flow and spray uniformity, and reducing the risk of pump and seal wear and blockage.

　　必須立即清洗的情形

　　Situations that require immediate cleaning

　　更換施工工地或噴灑材料批次后（防止不同配比或材料交叉污染）。

　　After changing the construction site or spraying material batch (to prevent cross contamination of different proportions or materials).

　　單次作業后罐內仍有殘留或噴嘴出現滴漏、霧化不均時（趁未干結及時沖洗）。

　　When there are still residues in the tank or when there is dripping or uneven atomization from the nozzle after a single operation (rinse promptly before it dries).

　　發現管路或泵體有異響、振動、流量明顯下降等異常征兆時（先清洗排查，必要時檢修）。

　　When abnormal signs such as abnormal noise, vibration, and significant decrease in flow rate are found in the pipeline or pump body (clean and investigate first, and repair if necessary).

　　遇雨雪或低溫天氣前（防止殘留漿體受凍膨脹損傷罐體與管路）。

　　Before encountering rain, snow or low temperature weather (to prevent residual slurry from freezing, expanding and damaging the tank and pipelines).

　　清洗要點與維護提示

　　Cleaning points and maintenance tips

　　作業結束后應盡快用清水將罐體、管網與噴嘴沖洗干凈，必要時配合適量清洗劑；清洗后將殘留水分排凈并擦干關鍵部位，減少銹蝕與結垢。

　　After the homework is completed, the tank, pipe network, and nozzle should be rinsed clean with clean water as soon as possible, and an appropriate amount of cleaning agent should be used if necessary; After cleaning, remove any residual moisture and dry key areas to reduce rust and scaling.

　　冬季停駛或低溫環境前，務必將水泵與管路內的水徹底放空，防止凍裂；長期停用也應排空并做防銹處理。

　　Before stopping operation in winter or in low-temperature environments, it is necessary to completely drain the water pump and pipeline to prevent freezing and cracking; Long term disuse should also be emptied and treated with rust prevention.

　　按設備使用手冊定期檢查泵油（或潤滑脂）、密封件與閥門狀態，保持良好潤滑與密封，延長使用壽命。

　　Regularly check the pump oil (or grease), seals, and valve status according to the equipment manual to maintain good lubrication and sealing, and extend the service life.

　　本文由 水泥撒布車出租 友情奉獻.更多有關的知識請點擊  http://www.dj1688.cn/   真誠的態度.為您提供為全面的服務.更多有關的知識我們將會陸續向大家奉獻.敬請期待.

　　This article is a friendly contribution from a cement spreader rental For more related knowledge, please click http://www.dj1688.cn/ Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.